Claas arion 410

[Weasel]

Hi there got an arion 410 and the heaters not working, checked the fuses and relays they all seem OK, fan just won't blow air, any ideas?

 

[Dman2]

Hi
Not sure if the 400s are the same as the 600s, but ours stopped working
Its was a bad contact onto the fan, cleaned them all up been no bother since

 

[daijd]

As above if it’s same as 600 arions there’s a black panel inbetween the front window and bonnet. The blowers are in under there. The connecting clip went dodgy on mine.

 

[thorpe]

your lucky if youve only got fan problems , ecu here and there not repairable!

 

[Weasel]

Hi
Not sure if the 400s are the same as the 600s, but ours stopped working
Its was a bad contact onto the fan, cleaned them all up been no bother since

Will try that

 

[Weasel]

your lucky if youve only got fan problems , ecu here and there not repairable!

Big bill coming?

 

[thorpe]

£2400 now £2100 on a stock order i think we will wate. + a load of labour finding the fault the laptop didnt find it , the mec did!

 

[Weasel]

£2400 now £2100 on a stock order i think we will wate. + a load of labour finding the fault the laptop didnt find it , the mec did!

That's terrible, how many hours on the tractor?

 

[thorpe]

3500 15 plate.

 

[lexion780tt]

Engine ECU?

 

[thorpe]

yes

 

[lexion780tt]

Though it would be were a pain on those cheaper from Deere than claas

 

[nails]

3500 15 plate.

Our Claas Ares is on its third ECU at 9000hrs. A genuine new one is about a grand but you can get re con ECU,s which are o.k. but have no warrantyso might not work out as cheap. the ECU unit on the Ares is mounted near the side of the block and probably gets too hot when working hard in hot weather. The multi pin plug to the ECU can be problematic and a clean with brake cleaner and a wiggle might get you going.

 

[lexion780tt]

Those little black ones under injection pump flex and vibrate too much if you put little rubber mounts on them seem to last much longer

 

[thorpe]

had ecu on ares repaired arions not repairable .

 

[lexion780tt]

What went wrong with it?

 

[thorpe]

fecked if i know fault codes flashing up like christmas lights!

 

[lexion780tt]

They were bad for just cutting out completely the used to get replaced in error sometime to cure water in fuel fault and lack if power but usually turned out to be low pressure pump above fuel filter on fuel tank

 

[Weasel]

3500 15 plate.

Mines has done 8000 no problems with ecu yet

 

[thorpe]

Mines has done 8000 no problems with ecu yet

good, our 620 has been great. the 630 which was an demontrator has had issues but they do perform and we like them a lot + dealer 2nd to none , but she is making me think of a change of colour but what colour?