Jd 6150 error-fault code =gutless

[vinnie123]

Jd has had more than one set of fuel filters recently and this keeps reappearing and the tractor is gutless has anyone else had this and found a cure ?

also this hvac error which appears to be air con? All filters clean etc . Any ideas appreciated before we have to call main stealer

 

[dan 6170r]

My 6170r has had them codes before
I change fuel filters and it fix that one for me
R u still on the same Batch of fuel ? Might be a bad Batch if fuel that’s keeps blocking filters
The other is one of the two motor fans these tractors have that has stopped working So I’ve been told by a fitter

 

[vinnie123]

My 6170r has had them codes before
I change fuel filters and it fix that one for me
R u still on the same Batch of fuel ? Might be a bad Batch if fuel that’s keeps blocking filters
The other is one of the two motor fans these tractors have that has stopped working So I’ve been told by a fitter

Not same batch of fuel, fresh delivery most weeks , we did wonder if fuel pumps wear out on these as they run constantly once keyed on ?

On hvac are the motors under the seat ?

 

[kill]

The other is one of the two motor fans these tractors have that has stopped working So I’ve been told by a fitter

I actually think R’s May have 3 fan motors as 2 below the seat and fairly sure there’s a fan some where in by the left mudguard as I had one replaced there in last 18 months as kept getting a error code similar to @vinnie123

 

[daveydiesel1]

Have u cleaned the gauze in the tank

 

[jonny]

It doesn’t have a locking fuel cap There not great for keeping water out

 

[vinnie123]

Have u cleaned the gauze in the tank

Will give this a try. Is it easy to access?

 

[daveydiesel1]

On a 30 series there was a plate under the floor mat so would presume a r series will have similar

 

[Andrew1983]

The hvac error is for the cab pressure fan well assuming that’s the same code as we had in 150 and 115. Actual ventilation system appears to work as normal just that bloody annoying buzzer going off all the time. Fans about £75 from dealer and not much to it. However it’s a complete bitch to get in to change. Pretty much the inside of the cab has to come out, seat, the floor under it, dozens of screws.
Ours are throwing the fuel filter error code more often than before too, must be something to do with age and build up of crap in tank or new diesel mixing with old, new tractor goes it’s 500h between services no bother, other 2 are only doing a couple hundred and start asking for filters

 

[Timbo]

the fan error is indeed the pressurizing fan to the left side of the seat- its not that bad to change once you've done one- I would ask dealer to change it . There is an option to have it de-enabled in the software meaning you wont have to replace the fan, but depends if your dealer will do that mod - in either case you'll need a fitter out to the tractor with Service Advisor, and he'd be able to look at the cause of the de-rate also.

The pick up tube sock, fuel filter base O-ring, porous fuel line(s) failed electric lift pump, bad connection or faulty rail pressure sensor and faulty SCV will all cause this low pressure derate. You can check the basics but inevitably will need Service Advisor to look at live data.

There have been countless software updates for the 6150R to address poor power delivery, poor running etc etc from its launch and yours undoubtedly would benefit from this once the root cause of the derate has been fixed.